Jun
06
2008
An old, disused upright-type refrigerator makes a useful smoker within certain limitations. It is well insulated and so will conserve heat, but, by the nature of its original function, is not designed to stand heat, so it is only suitable as a cold smoker. A hole about 10 in. square or round should be cut in the bottom of the fridge, which should be raised off the ground and supported on a square built of concrete blocks, open at the front to allow the fire to be placed within the square of blocks. Alternatively, the device can be used in conjunction with the remote fire pit and underground smoke tunnel, and as a means of draught control two or three 2-in. holes can be cut in the top of the fridge; better still, it can be fitted with a length of stovepipe, protruding from the top and preferably fitted with a damper. Continue Reading »
Jun
06
2008
While on the subject of smoking equipment, perhaps a further word will not be out of place regarding the mechanical smoker referred to earlier, should any home smoker feel inclined to invest in one of these rather elaborate pieces of equipment.
I imagine that all large commercial fish or bacon smoking concerns in Britain will by now have ceased to use traditional equipment and will employ mechanical equipment exclusively. The modern smoker which I am acquainted with is the Torry Kiln, which is marketed by Afos Limited, Anlaby, Hull, North Humberside. Some of these commercial kilns are very large, costing several thousands of pounds, but the only model with which the home smoker might need to concern himself is the Torry Mini Kiln. This kiln is based on the same principles as the large commercial smoking units, and has a maximum capacity of 56 lb (approx. 25 kilos). Continue Reading »
Jun
06
2008
The first piece of smoking equipment I had any experience with was the Abu Smokebox, which is manufactured by Abu Svangsta of Sweden, a famous firm of fishing tackle manufacturers. The Abu measures about 12 x 7 x 4 in. deep and on account of its small size, the potential is very limited. The Abu works on a different principle from other smoke units, and is said to ‘pressure smoke‘. A bed of fine sawdust is spread on its floor, and a combined drip tin and wire rack placed over the sawdust, on which is placed the food to be smoked. A small methylated spirit burner under the Abu supplies instant heat, and the sliding lid fits fairly tightly into place. Here the process differs from other smoking techniques, which allow for the free passage of smoke out of the top of the sides of the unit. The smoke has to force its way out of the sides of the lid, causing smoke pressure inside. High temperatures are generated within the Abu and the food cooks in the time it takes for the meths to burn out, which is usually about 20 minutes. Continue Reading »
Jun
06
2008
The traditional cold smoker
Cold smoking, at temperatures of around 80° F, is an essential operation for the production of smoked salmon, which is eaten raw, of other smoked fish, such as kippers, finnan haddocks, cod and haddock fillets and cod roes, and fillets of beef. Cold smoking is also an essential part of the initial processing of all other products which are ultimately hot smoked.
In the commercial fish smoking industry, the traditional cold smoking kiln is simply a large chimney with ventilators placed up the shaft at intervals, so that draughts can be controlled. The fire is lit in a large hearth either at the foot of the kiln or in a fire pit a few feet away, the smoke being conducted along an underground flue to the kiln by natural draught. Continue Reading »
Jun
05
2008
Wood for smoke production
The essential commodity upon which the success of any smoke curing operation depends is a suitable supply of smoke- producing fuel. What is required is a fuel which will burn slowly and steadily, requiring the minimum of attention, and without producing too much heat. Non-resinous woods must be used as resinous soft woods impart a bitter flavour to the food, although giving it an attractive colour. Some people mix a proportion of softwood sawdust with that of the hardwood variety, which they claim adds colour without impairing the flavour of the smoked product. Continue Reading »
May
30
2008
Some time ago, I had a commercial association with a North Country farmer who, as an expanding sideline, had a smoked food business, supplying many first-class hotels, mainly in the western half of the country. He did not process smoked foods himself but had it custom smoked for him by people like myself. He was particularly keen to put smoked beef on the market — what type or how processed, he did not specify. The idea was left in abeyance for some time, as in any case I was fairly well occupied in smoking ducks, quail and pheasants for him, and it was not until the matter of smoked beef was raised by a first-class butcher of my acquaintance, who had enjoyed my smoked quail, that I pursued the matter further. Continue Reading »
May
29
2008
Shrimps can either be cold smoked whole or as peeled meats. For the former method, the shrimps should have the heads removed and are then washed and drained for 30 minutes. They are then brined for 30 - 60 minutes (according to preference) in 40% brine (1 lb 3 oz salt to 1 gallon water), then boiled in the brine or in plain water, again according to taste, for 30 minutes. The shrimps are then allowed to air dry on racks for 2 hours.
The shrimps are then placed in the kiln and smoking is carried out for 1 - 11/2 hours at a temperature of 80° F. The yield of smoked meats after shelling is approximately 36% of the whole raw shrimp weight. Continue Reading »
May
28
2008
There are three varieties of quail in Britain. There is the European quail which occasionally spends the summer and early autumn here, sometimes breeding successfully before migrating back to the continent before winter sets in. For many years, even before the Protection of Birds Act came into being, the quail has been a completely protected bird in Britain, which is no bad thing considering the persecution they suffer at the hands of our French and Italian neighbours. Continue Reading »
May
27
2008
The idea that it might be a feasible proposition to smoke pheasants was entirely my own. I am not a fisherman myself but I do shoot and cc-isequently have a fair quantity of game through my hands every season.
We are quite fond of pheasants, but after a time we become tired of them. My wife has managed to purloin a recipe from the daughter of one of the hereditary Scottish clan chiefs, which involves doing a roast pheasant up, off the bone, with cream, garlic and button mushrooms and serving the result on a bed of savoury rice. Continue Reading »
May
25
2008
Razor clams should first be steamed for 10 minutes to open them. The meats should be shaken out and the clams should be cleaned by removing the stomachs and splitting open the necks. They should then be washed and cut into sections. The clams should be soaked in 60% brine (1 lb 14 oz salt to 1 gallon of water) for 5 minutes, then rinsed in cold water and drained on racks for 15 minutes. Continue Reading »
May
24
2008
Woodcock are something of a delicacy at any time. They are not normally obtainable in any significant numbers and, roasted on toast in the traditional manner, are appreciated by sportsmen gourmets.
However, I can thoroughly recommend smoked woodcock, and one or two can easily be smoked alongside other species, such as pheasants or quail. When in good condition the woodcock is a fat, moist bird and will retain a good proportion of moisture during smoking. Continue Reading »
May
23
2008
Hamburgers
Equal quantities of good quality beef and pork should be minced and bound with egg yolk and basic seasoning to form cakes. These should be placed on a wire rack, with a dripping tin underneath, in a smoke oven pre-heated to 200 - 225° F. There should be plenty of dense smoke as the hamburgers will only be in the oven for about 30 minutes. They can either be left in the same position for the whole process, or can be turned halfway through. Continue Reading »
May
22
2008
The traditional smoked foods of Britain and Europe are not normally eaten straight from the smoker. In all cases it is usual to allow the food to ‘mature’ for at least 24 hours after smoking, so that the best possible flavour can be enjoyed. Hot smoked foods are almost invariably eaten cold, as are some cold smoked delicacies such as salmon, cod roes and fillets of beef. Others, like kippers, cold smoked mackerel or finnan haddocks, not to mention ordinary smoked bacon, are cooked before eating, but even these products are not used straight from the smoker. Continue Reading »
May
21
2008
Notes on measurement
Two ordinary mercury-in-glass thermometers are required with a range of about 50-100° F. They must be inserted through holes in the wall of the kiln a few inches apart so that the bulbs project well into the smoke stream. One of the thermometers (the ‘wet bulb‘) has a muslin bag or sleeve tied round the bottom inch or two of the stem, so that it completely surrounds the mercury bulb.
Before a reading is taken, this bag is moistened by dipping in clean water, preferably distilled water, and after putting back in position, the reading of the thermometer is taken when it is steady after about half a minute. The ordinary temperature of the dry bulb should be read on the other thermometer at the same time as that of the wet bulb. The smoke should not pass over the wet bulb immediately before the dry bulb in case the air gets cooled by evaporation before affecting the dry bulb. Continue Reading »